Product ID:83208 SHELL VM&P NAPHTHA-EC
MSDS Date:04/26/1991
FSC:6850
NIIN:00F033030
MSDS Number: BTBNG

SHELL OIL CO

1 SHELL PLZ
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461

Info Phone: 800 832-3766

Cage: SHELO

SHELL OIL COMPANY

4320 HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE *93/4*

CAS: 64742-89-8

Fraction By Weight: 93%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5.6%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYL BENZENE

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 1.4%

OSHA PEL 435 MG/CUM

ACGIH TLV: 434 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:NO Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION: ASPIRATION (BREATHING) OF
VOMITUS INTO THE LUNGS MUST BE AVOIDED AS EVEN SMALL QUANTITIES MAY
RESULT IN ASPIRATION PNEUMONITIS. INHALATION: CNS DEPRESSION
W/GIDDINESS, HEADACHE, DIZZINESS & NAUSEA. EXTREME CASES,
UNCONSCIOUSNESS& DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: ASPIRATION PNEUMONITIS MAY BE
EVIDENCED BY COUGHING, LABORED BREATHING & CYANOSIS (BLUISH SKIN);
IN SEVERE CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/WATER. FOLLOW BY WASHING W/SOAP & WATER. INHALATION: REMOVE
VICTIM TO FRESH AIR & PROVUDE OXYGEN IF BREATHING IS DIFFICULT.
GIVE ARTIFICIAL RES PIRATION IF NOT BREATHING. INGESTION: DON'T
INDUCE VOMITING. IF VOMITING OCCURES SPONTANEOUSLY. KEEP HEAD BELOW
HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. OBTAIN MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:57F
Lower Limits:1
Upper Limits:7
Extinguishing Media:WATER FOG/FOAM/DRY CHEMICAL/CO2. DON'T USE DIRECT
STREAM OF WATER. PRODUCT WILL FLOAT/CAN BE REIGNITED ON SURFACE
WATER.
Fire Fighting Procedures:CLEAR AREA OF UNPROTECTED PERSONNEL. DON'T
ENTER CONFINED FIRE SPACE W/OUT BUNKER GEAR & SCBA.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.

Spill Release Procedures:ELIMINATE IGNITION SOURCES. GROUND HANDLING
EQUIPMENT TO PREVENT SPARKING. LARGE: EVACUATE HAZARD AREA OF
UNPROTECTED PERSONNEL. WEAR APPROPRIATE RESPIRATOR & PROTECTIVE
CLOTHING. SHUT OFF LEAK SOURCE IF SAFE TO DO SO. DIKE & CONTAIN.
(SUPP)

Handling and Storage Precautions:DON'T PRESSURIZE DRUM CONTAINERS TO
EMPTY. BOND & GROUND TRANSFER CONTAINERS & EQUIPMENT. USE
W/ADEQUATE VENTILATION.
Other Precautions:KEEP LIQUID & VAPOR AWAY FROM HEAT, SPARKS, FLAME.
SUFFICIENTLY HOT SURFACES MAY IGNIE LIQUID PRODUCT. VAPORS MAY
ACCUMULATE & TRAVEL TO IGNITON SOURCES DISTANT FROM HANDLING SITE,
FLASH-FIRE CAN RESU LT. KEEP CONTAINERS CLOSED IF NOT USING.

Respiratory Protection:NIOSH APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE.
Ventilation:EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL VAPOR
CONCENTRATIONS.
Protective Gloves:CHEMICAL-RESISTANT
Eye Protection:SAFETY GLASSES/GOGGLES
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING
Work Hygienic Practices:AIR-DRY CONTAMINATED CLOTHING IN A WELL
VENTIALTED AREA. THEN LAUNDER BEFORE REUSING.
Supplemental Safety and Health
IF VAPOR CLOUD FORMS, WATER FOG MAY BE USED TO SUPRESS; REMOVE W/VACUUM
TRUCKS OR PUMP TO STORAGE/SALVAGE VESSELS. SOAK RESIDUE W/ABSORBENT
AS CLAY/SAND/OTHER SUITABLE MATAERIAL; PLACE IN NON-LEAKING
CONTAINER FOR DISPOSAL. FLUSH AREA W/WATER TO REMOVE TRACE RESIDUE.

Boiling Pt:B.P. Text:249-273
Vapor Pres:26
Vapor Density:3.8
Spec Gravity:0.76
Evaporation Rate & Reference:(N BU AC=1): 1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID W/HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, FLAME
Hazardous Decomposition Products:CO & UNIDENTIFIED ORGANIC COMPOUNDS
MAY BE FORMED DURING COMBUSTION.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.